Product ID:D-701 DEVELOPER
MSDS Date:03/15/1989
FSC:6850
NIIN:01-265-2742
MSDS Number: BGSVV

MET-L-CHEK COMPANY

1639 EUCLID ST
SANTA MONICA, CA 90404-3723
US

Emergency Phone: 213-450-1111

Info Phone: 213-450-1111

Cage: 98733

MET-L-CHEK COMPANY

00000 SANTA MONICA, CA 90404 US

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: <95.00%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MATERIAL IS PRIMARILY CNS DEPRESSANT.
INHALATION CAN CAUSE IRRITATION OF RESP TRACT SYSTEM.SKIN OR EYES
CONTACT MAY RESULT IN DISCOMFORT,PAIN AND IRRITATION. SWALLOWING
MAY RESULT IN IRRITATION OF THE MOUTH AND GI TRACT.
Effects of Overexposure:EYES: MAY CAUSE IRRITATION; SKIN: SLIGHT
IRRITATION ON CONTACT WITH LIQUID.MAY CAUSE DERMATITIS; INHALATION:
VAPORS MAY IRRITATE RESP TRACT. CAUSES
DIZZINESS,HEADACHE,DISCOMFORT,PAIN OR IRRITATION OF MOUTH. MAY
CAUSE NAUSEA WITH VOMITING. INGESTION: MAY CAUSE IRRITATION OF GI
TRACT.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT. MAY CAUSE
DERMATITIS.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.GET MEDICAL
HELP IF IRRITATION OCCURS OR PERSISTS; SKIN: FLUSH WITH WATER.WASH
WITH LUKE WARM WATER & SOAP.GET MEDICAL HELP FOR PERSISTING
IRRITATION; IN HALATION: REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE
ARTIFICIAL RESPIRATION.GET MED ASST IF NEEDED; INGESTION: IF
SWALLOWED, DO NOT INDUCE VOMITING. IMMEDIATELY GET MEDICAL
ASSISTANCE.

Flash Point:NONE
Lower Limits:7.0
Upper Limits:15.0
Extinguishing Media:PER MFR,USE WATER,DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH-APPROVED PRESSURE DEMAND
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:PER MANUFACTURER,VAPORS CONCENTRATED IN
CONFINED/POORLY VENTILATED AREA CAN BE IGNITED UPON CONTACT WITH
HIGH ENERGY SPARK,FLAME OR HIGH INTENSITY HEAT SOURCE.

Spill Release Procedures:ELIMINATE IGNITION SOURCES.PROVIDE MAX
VENTILATION.WEAR EYE,SKIN,AND RESPIRATORY PROTECTION.SOAK UP WITH
ABSORBENT SUCH AS SAW DUST OR VERMICULITE.SWEEP UP AREA. AVOID
DUSTING.KEEP WASTE IN SEALED CON TAINERS PENDING DISPOAL
INSTRUCTIONS.DONOT FLUSH.

Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF
HEAT/IGNITION.STORE IN COOL,DRY & VENTILATED AREA.DO NOT STORE NEAR
OXIDIZING MATERIAL;AVOID PHYSICAL DAMAGE TO CONTAINERS.
Other Precautions:MINIMIZE SKIN CONTACT.AVOID BREATHING VAPORS.USE ONLY
WITH ADEQUATE VENTILATION.AVOID PROLONGED & REPEATED CONTACT WITH
SKIN.DO NOT SWALLOW.VAPORS ARE HEAVIER THAN AIR WILL COLLECT IN LOW
AREAS.DO NOT ENTER WITHOUT RESPIRATORY PROTECTION.

Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR USES WHEN
VAPORS/MIST CONCENTRATIONS ARE BELOW TLV/PEL LIMITS.WEAR NIOSH
APPROVED ORGANIC VAPOR CHEMICAL CARTRIDGE OR CANISTER TYPE
RESPIRATOR WHEN TLV EXCEEDS OR IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) TO MAINTAIN TLV OR
BELOW TLV LIMITS.
Protective Gloves:VITON
Eye Protection:SPLASH-PROOF GOGGLES
Other Protective Equipment:CHEMICAL RESISTANT APRON TO PREVENT
CLOTHING/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP & WATER BEFORE EATING,
SMOKING OR USING TOILET FACILITIES;DO NOT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
NSN FOR TYPE I,FORM D DEVELOPER OF MIL-I-25135; PER QPL-25135-15, D-701
DEVELOPER IS A QUALIFIED PRODUCT FOR THIS NSN. UNIT CONTAINER
QUANTITY IS: 1 GAL. PER QPL-25135-15, MANUFACTURE CAN SUPPLY EITHE
R ONE OF THE FOLLOWING DEVELOPERS: D-70,D-701,D-703 DEPENDING UPON
THE USE.

HCC:T4
Boiling Pt:B.P. Text:162F,72C
Vapor Pres:135
Vapor Density:4.54
Spec Gravity:1.300-1.320
Evaporation Rate & Reference:0.35,(ETHYL ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY WHITE LIQUID WITH ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL,STRONG ALKALI/BASES (CAUSTIC SODA,CAUSTIC POTASH).
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:WHEN INVOLVED IN FIRE,
1,1,1-TRICHLOROETHANE EMITS HIGHLY TOXIC AND IRRITATING HYDROGEN
CHLORIDE AND PHOSGENE FUMES.

Waste Disposal Methods:PER MANUFACTURER, THE WASTE MUST BE DISPOSED OF
IN A PERMITTED HAZARDOUS WASTE MANAGEMENT FACILITY IN FULL
COMPLIANCE WITH ALL FEDERAL STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.